Kia Carens: Button Engine Start System / ESCL(Electronic Steering Column Lock) Repair procedures

Kia Carens RP (2013-2018) Service Manual / Body Electrical System / Button Engine Start System / ESCL(Electronic Steering Column Lock) Repair procedures

Removal
1.
Disconnect the negative(-) battery terminal.
2.
Remove the crash pad lower panel.
(Refer to Body - "Crash Pad Lower Panel")
3.
Remove the steering column upper and lower shrouds.
(Refer to Body - "Steering Column Shroud Panel")
4.
Disconnect the electronic steering column lock connector (A).

5.
Remove the electronic steering column lock.
(Refer to Steering System - "Steering Column And Shaft")
Installation
1.
Install the electronic steering column lock (A).
  
Do not reuse the shear bolts.
When installing the new shear bolts to the electronic steering column lock, tighten the shear bolts until its head is cut off.
Tightening torque :
7 ~ 13 N.m (0.7 ~ 1.3 kgf.m, 5 ~ 9.4 lb.ft)

2.
Install the steering column.
3.
Install the crash pad lower panel.
ESCL(Electronic Steering Column Lock) Components and components location
Component ...

Front / Rear Parking Assist System
...

Other information:

Kia Carens RP (2013-2018) Service Manual: Radiator Repair procedures


Inspection Radiator Cap Testing 1. Remove the radiator cap, wet its seal with engine coolant, and then install it on a pressure tester. 2. Apply a pressure of 93.16 ~ 122.58 kPa (0.95 ~ 1.25 kgf/cm², 13.51 ~ 17.78 ...

Kia Carens RP (2013-2018) Service Manual: Accelerator Pedal Repair procedures


Removal 1. Turn the ignition switch OFF and disconnect the negative (-) battery cable. 2. Disconnect the accelerator position sensor connector (A). 3. Remove the installation bolt (B) and nuts (C), a ...

Copyright © www.kicaman.com 2015-2023