Kia Carens: Air conditioning System / Compressor oil Repair procedures

Kia Carens RP (2013-2018) Service Manual / Heating,Ventilation And Air Conditioning / Air conditioning System / Compressor oil Repair procedures

Oil Specification

1.	The HFC-134a or HFO-1234yf system requires synthetic (PAG) compressor oil whereas the R-12 system requires mineral compressor oil. The two oils must never be mixed.

2.	Compressor (PAG) oil varies according to compressor model. Be sure to use oil specified for the model of compressor.

Handling of Oil

1.	The oil should be free from moisture, dust, metal powder, etc.

2.	Do not mix with other oil.

3.	The water content in the oil increases when exposed to air. After use, seal oil from air immediately. (HFC-134a or HFO-1234yf Compressor Oil absorbs moisture very easily.)

4.	The compressor oil must be stored in steel containers, not in plastic containers.

Compressor Oil Check

The oil used to lubricate the compressor circulates with the refrigerant.

Whenever replacing any component of the system or a large amount of gas leakage occurs, add oil to maintain the original amount of oil.

Oil total volume in system

PAG (FD46XG) 100 ± 10cc (3.52 ± 0.35oz.)

Oil Return Operation

There is close affinity between the oil and refrigerant.

During normal operation, part of the oil recirculates with the refrigerant in the system. When checking the amount of oil in the system, or replacing any component of the system, the compressor must run in advance for oil return operation. The procedure is as follows:

1.	Open all the doors and engine hood.

2.	Start the engine and air conditioning switch to "ON" and set the blower motor control knob at its highest position.

3.	Run the compressor for more than 20 minutes between 800 and 1,000 rpm in order to operate the system.

4.	Stop the engine.

Components and components location

Component Location Index Engine Room [GSL] 1. Receiver-drier 2. Condenser 3. Ambient temperature Sensor 4. Compressor 5. Discharge Hose ...

Refrigerant Line Repair procedures

Replacement 1. Discharge refrigerant from the refrigeration system. 2. Replace faulty tube or hose. ...

Other information:

Kia Carens RP (2013-2018) Owners Manual: Sliding the sunroof

When the sunshade is closed If you pull the sunroof control lever backward, the sunshade will slide all the way open then the sunroof glass will slide all the way open.To stop the sunroof movement at any point, pull or push the sunroof control lever momentarily. When the sunshade is opened If you ...

Kia Carens RP (2013-2018) Owners Manual: High - beam operation

1. Turn the light switch to the headlight position. 2. Push the lever away from you. The high-beam indicator will light when the headlight high beams are switched on. To prevent the battery from being discharged, do not leave the lights on for a prolonged time while the engine is not running ...