Kia Carens: Air conditioning System / Refrigerant Line Repair procedures

Kia Carens RP (2013-2018) Service Manual / Heating,Ventilation And Air Conditioning / Air conditioning System / Refrigerant Line Repair procedures

Replacement
1.
Discharge refrigerant from the refrigeration system.
2.
Replace faulty tube or hose.
  
Cap the open fittings immediately to keep moisture or dirt out of the system.
3.
Tighten the bolt or nut joint to the specified torque.
  
Connections should not be torque tighter than the specified torque.
4.
Evacuate air in the refrigeration system and charge system with refrigerant.
Specified amount
550 ± 25g (19.4 ± 0.88oz.)
5.
Inspect for leakage of refrigerant.
Using a gas leak detector, check for refrigerant leakage.
6.
Inspect A/C operation.
Compressor oil Repair procedures
Oil Specification 1. The HFC-134a or HFO-1234yf system requires synthetic (PAG) compressor oil whereas the R-12 system requires mineral compressor oil. The two ...

Compressor Description and operation
Description The compressor is the power unit of the A/C system. It is located on the side of engine block and driven by a V-belt of the engine. The compressor changes low pr ...

Other information:

Kia Carens RP (2013-2018) Service Manual: Valve Body Components and components location


Components Location 1. Pressure Control Valve(PCV) adjust screw 2. Oil temperature sensor 3. Line Pressure Control Solenoid Valve 4. SS-A Solenoid Valve(ON/OFF) 5. SS-B Solenoid Valve(ON/OFF) 6. Overdrive Clutch Control Solenoid Valve(OD/C) 7. ...

Kia Carens RP (2013-2018) Service Manual: Rear Door Inside Handle Repair procedures


Replacement 1. Remove the rear door trim. (Refer to Rear Door - "Rear Door Trim") 2. After loosening the mounting screws, then remove the rear door inside handle (A). 3. Dis ...

Copyright © www.kicaman.com 2015-2026