Kia Carens: Heating,Ventilation And Air Conditioning / Troubleshooting
Kia Carens RP (2013-2018) Service Manual / Heating,Ventilation And Air Conditioning / Troubleshooting
| Troubleshooting |
| Problem Symptoms Table |
Before replacing or repairing air conditioning components, first determine if
the malfunction is due to the refrigerant charge, air flow or compressor.
Use the table below to help you find the cause of the problem. The numbers indicate
the priority of the likely cause of the problem. Check each part in order. If
necessary, replace these parts.
After correcting the malfunction, check the complete system to ensure that performance
is satisfactory.
Standard:
|
Symptom |
Suspected Area |
|
No blower operation |
1. Blower fuse |
|
2. Blower relay |
|
|
3. Blower motor |
|
|
4. Power mosfet |
|
|
5. Blower speed control switch |
|
|
6. Wire harness |
|
|
No air temperature control |
1. Engine coolant capacity |
|
2. Heater control assembly |
|
|
No compressor operation |
1. Refrigerant capacity |
|
2. A/C fuse |
|
|
3. Clutch limiter |
|
|
4. Compressor |
|
|
5. A/C pressure transducer |
|
|
6. A/C switch |
|
|
7. Evaporator temperature sensor |
|
|
8. Wire harness |
|
|
Vented air not cold |
1. Refrigerant capacity |
|
2. Refrigerant pressure |
|
|
3. Drive belt |
|
|
4. Clutch limiter |
|
|
5. Compressor |
|
|
6. A/C pressure transducer |
|
|
7. Evaporator temperature sensor |
|
|
8. A/C switch |
|
|
9. Heater control assembly |
|
|
10. Wire harness |
|
|
Insufficient cooling |
1. Refrigerant capacity |
|
2. Drive belt |
|
|
3. Clutch limiter |
|
|
4. Compressor |
|
|
5. Condenser |
|
|
6. Expansion valve |
|
|
7. Evaporator |
|
|
8. Refrigerant lines |
|
|
9. A/C pressure transducer |
|
|
10. Heater control assembly |
|
|
No engine idle-up when A/C switch ON |
1. Engine ECM |
|
2. Wire harness |
|
|
No air inlet control |
1. Heater control assembly |
|
No mode control |
1. Heater control assembly |
|
2. Mode actuator |
|
|
No cooling fan operation |
1. Cooling fan fuse |
|
2. Fan motor |
|
|
3. Engine ECM |
|
|
4. Wire harness |
Special service tools
Special Service Tools
Tool (Number and name)
Illustration
Use
09977-3R000
Clutch bolt remover
Rem ...
Other information:
Kia Carens RP (2013-2018) Service Manual: Repair procedures
Removal 1. Disconnect the negative (-) battery terminal. 2. Remove the steering wheel. (Refer to Steering System - "Steering Wheel") 3. Remove the steering column upper and lower shrouds ...
Kia Carens RP (2013-2018) Service Manual: SS-A Solenoid Valve(ON/OFF) Description and operation
Description • SS-A solenoid valve is ON/OFF type. • When TCM supplies variable current to solenoid valve, speed range is changed by operating the solenoid valve. SS-A Solenoid Valve operation table ...
Copyright © www.kicaman.com 2015-2025
